CriticalCommonEngine

Nissan Caravan: ZD30 electronic injector pump failure

ZD30 electronic injector pump failure is a common engine fault on the Nissan Caravan on the 2001–2012 cars, and we rate it critical. Putting it right costs ≈A$2,300 to ≈A$4,140 at independent workshop rates, shown as an approximate guide in Australian dollars. Below is what goes wrong, the symptoms to notice on a test drive, where to look, and what to ask the seller before you hand over any money. It is one of 9 documented faults on the Nissan Caravan.

Vehicle: Nissan Caravan
Engine: ZD30
Years: 2001–2012
Fuel: diesel
System: Engine

This page covers the Nissan Caravan as a model. Some faults only affect particular engines or build years — enter a plate below to narrow the list to one car.

All Nissan Caravan faults9 documented faults on this model

What you are looking at

What goes wrong

The electronically controlled injection pump on the direct-injection ZD30 is a well documented failure point. The pump runs hot and its internal electronics and metering components wear, causing hard starting, stalling and eventually a no-start. Reconditioned pumps are expensive and fitting/coding adds labour. Diesel specialists recommend clean fuel and filter changes on schedule; some owners fit a lift pump to reduce pump load and heat.

What you would notice

Hard starting, especially when hot
Intermittent stalling then restarting once cooled
Engine cutting out at speed
Check-engine light with fuel pump / injection codes

How to check it

Where to look. Injection pump on the side of the 3.0 diesel engine, driven off the timing gears

Start the van from stone cold, then again after a decent hot drive - hot-start hesitation is the classic early sign.
Ask a diesel shop to read fault codes before purchase.
Check the fuel filter service history; contaminated fuel kills these pumps.

Parts involved: Fuel injector.

What it costs to put right

≈A$2,300 to ≈A$4,140 at independent workshop rates, shown as an approximate guide in Australian dollars. That is for this job on its own, not for the car.

An estimate, converted to Australian dollars, for the repair as normally carried out. What a specific car costs depends on which part has failed and what it damaged on the way — treat this as the floor for a negotiation, not a quote.

Ask the seller

“Has the injector pump ever been replaced or reconditioned - is there a receipt?”
“How often has the fuel filter been changed?”
“Does it ever stall or refuse to start when hot?”

Now check the Nissan Caravan you are actually looking at

Everything above is true of the model, and it is free. What it does not tell you is whether THIS car still has money owing on it, has been written off or reported stolen, what kms it showed in past sale ads, whether it has had accident repair claims and what it is worth today. That comes from the official records for that plate. Enter the plate and its state for the A$17.90 Vehicle Check, or the full history from A$24.99.

Where this comes from

The failure described above is documented in the sources below. The inspection instructions and the cost estimate are KickTyres’ own interpretation of them.

Patrol 4x4 forum thread 'Zd30 injector pump problem' (#416801)
Nissan Forums thread 'Zd30 injector pump' (#273615)
Patrol 4x4 thread 'Injector Pump Failure?' (#141185)

Nissan Caravan buyer questions

Is zd30 electronic injector pump failure serious on a Nissan Caravan?

We rate it critical and common on the Nissan Caravan. The electronically controlled injection pump on the direct-injection ZD30 is a well documented failure point. The pump runs hot and its internal electronics and metering components wear, causing hard starting, stalling and eventually a no-start. Reconditioned pumps are expensive and fitting/coding adds labour. Diesel specialists recommend clean fuel and filter changes on schedule; some owners fit a lift pump to reduce pump load and heat.

How much does it cost to fix on a Nissan Caravan?

≈A$2,300 to ≈A$4,140 at independent workshop rates, shown as an approximate guide in Australian dollars. That figure is for this job on its own. A car showing the symptoms on this page is usually worth either walking away from or negotiating down by at least the repair figure.

Which Nissan Caravan years are affected?

Our research records this fault on the 2001–2012 Nissan Caravan. Build dates move around, especially on imported cars, so treat the range as the years to look hardest at rather than a guarantee either way. The official records tell you the exact build and first registration date for the car in front of you.

How do I check for it before I buy?

Start the van from stone cold, then again after a decent hot drive - hot-start hesitation is the classic early sign. Ask a diesel shop to read fault codes before purchase. Check the fuel filter service history; contaminated fuel kills these pumps. Look here: Injection pump on the side of the 3.0 diesel engine, driven off the timing gears