MajorCommonTransmission

Volkswagen Up: ASG automated-manual gearbox — jerky, hesitant shifts and clutch-actuator wear

ASG automated-manual gearbox — jerky, hesitant shifts and clutch-actuator wear is a common transmission fault on the Volkswagen Up on the 2011–2023 cars, and we rate it major. Putting it right costs ≈A$830 to ≈A$2,580 at independent workshop rates, shown as an approximate guide in Australian dollars. Below is what goes wrong, the symptoms to notice on a test drive, where to look, and what to ask the seller before you hand over any money. It is one of 5 documented faults on the Volkswagen Up.

Vehicle: Volkswagen Up
Years: 2011–2023
Fuel: petrol
Gearbox: auto
System: Transmission

This page covers the Volkswagen Up as a model. Some faults only affect particular engines or build years — enter a plate below to narrow the list to one car.

All Volkswagen Up faults5 documented faults on this model

What you are looking at

No photograph available

We do not hold a verified photograph of the Clutch yet. We would rather show none than show a picture of a different part.

What goes wrong

The optional ASG (a single-clutch robotised manual, badged 'automatic') is the Up's most complained-about drivetrain. Owners report slow, jerky gear changes, a distinct pause and power drop-off between shifts, no creep function in stop-start traffic and awkward hill starts. Roughness typically worsens from around 40,000 km and can be caused by the clutch-actuator and clutch itself wearing, worn synchro/selector components, or software/adaptation that has drifted out of range. Some cars throw shift-related fault codes and drop into limp mode. It is mechanically a manual with a robot clutch, so much of the behaviour is design, but genuine actuator and clutch failures do occur. The SEAT Mii and Skoda Citigo twins share this box.

What you would notice

Jerky or lurching gear changes, especially at low speed
Long pause and loss of drive between shifts
No creep — car rolls back on hills
Awkward, hesitant hill starts
Shift warning light or intermittent limp mode

How to check it

Where to look. Transaxle / clutch actuator on gearbox bellhousing

On the test drive from cold, pull away gently then briskly in traffic and feel for excessive lurching, long shift pauses or drive dropping out.
Check for stored transmission fault codes and confirm the clutch has been adapted/serviced.
Ask whether it is an ASG or genuine manual before buying.

Parts involved: Clutch.

What it costs to put right

≈A$830 to ≈A$2,580 at independent workshop rates, shown as an approximate guide in Australian dollars. That is for this job on its own, not for the car.

An estimate, converted to Australian dollars, for the repair as normally carried out. What a specific car costs depends on which part has failed and what it damaged on the way — treat this as the floor for a negotiation, not a quote.

Ask the seller

“Is this an ASG automated-manual or a normal manual?”
“Has the clutch actuator ever been replaced or re-adapted?”
“Does it ever jerk badly or drop into limp mode in traffic?”

Now check the Volkswagen Up you are actually looking at

Everything above is true of the model, and it is free. What it does not tell you is whether THIS car still has money owing on it, has been written off or reported stolen, what kms it showed in past sale ads, whether it has had accident repair claims and what it is worth today. That comes from the official records for that plate. Enter the plate and its state for the A$17.90 Vehicle Check, or the full history from A$24.99.

Where this comes from

The failure described above is documented in the sources below. The inspection instructions and the cost estimate are KickTyres’ own interpretation of them.

Up Owners Club forum — 'ASG problems' owner threads (upownersclub.co.uk)
ASR Gearbox Repairs — 'Volkswagen Up Common Gearbox Problems'
AUTODOC blog — VW common problems and faults
Autoguide — 'Volkswagen Up Problems: The Honest Guide'

Volkswagen Up buyer questions

Is asg automated-manual gearbox — jerky, hesitant shifts and clutch-actuator wear serious on a Volkswagen Up?

We rate it major and common on the Volkswagen Up. The optional ASG (a single-clutch robotised manual, badged 'automatic') is the Up's most complained-about drivetrain. Owners report slow, jerky gear changes, a distinct pause and power drop-off between shifts, no creep function in stop-start traffic and awkward hill starts. Roughness typically worsens from around 40,000 km and can be caused by the clutch-actuator and clutch itself wearing, worn synchro/selector components, or software/adaptation that has drifted out of range. Some cars throw shift-related fault codes and drop into limp mode. It is mechanically a manual with a robot clutch, so much of the behaviour is design, but genuine actuator and clutch failures do occur. The SEAT Mii and Skoda Citigo twins share this box.

How much does it cost to fix on a Volkswagen Up?

≈A$830 to ≈A$2,580 at independent workshop rates, shown as an approximate guide in Australian dollars. That figure is for this job on its own. A car showing the symptoms on this page is usually worth either walking away from or negotiating down by at least the repair figure.

Which Volkswagen Up years are affected?

Our research records this fault on the 2011–2023 Volkswagen Up. Build dates move around, especially on imported cars, so treat the range as the years to look hardest at rather than a guarantee either way. The official records tell you the exact build and first registration date for the car in front of you.

How do I check for it before I buy?

On the test drive from cold, pull away gently then briskly in traffic and feel for excessive lurching, long shift pauses or drive dropping out. Check for stored transmission fault codes and confirm the clutch has been adapted/serviced. Ask whether it is an ASG or genuine manual before buying. Look here: Transaxle / clutch actuator on gearbox bellhousing