Skip to content
KickTyres
Toyota2006–2018 Critical issues documented

Toyota Auris E150: common faults & what to check

The E150 is the Toyota Auris built 2006–2012. The engines documented for it are the 1.5 petrol and 1.8 petrol. Of the 5 faults documented for the Auris, 3 apply to this generation, each with its symptoms, what to inspect and a typical repair cost. Free, no account needed.

Check this exact Toyota Auris

  • Money owing
  • Written off
  • Accident claims
  • Odometer history

An Australian plate goes to the A$17.90 Vehicle Check: money owing, write-off, stolen and rego. Full History adds past kms, accident claims and market value from A$24.99. The free fault check for this model needs the generation and engine, pick them below.

5

Documented faults

Critical

Most serious

≈A$370–4,140

Typical repair

18

Service milestones

You're looking at the E150

2 engine variants are documented for this generation. Pick yours to narrow further, or keep reading for the generation as a whole.

Choose a different generation

Now narrow it to the engine

A 1.8 and a 2.4 of the same car do not fail the same way, so the faults below narrow to the engine as well as the year. Free, no account needed.

A 2006 Toyota Auris is the E150 generation (2006 to 2012).

Start your free check on this Toyota Auris

No plate needed. You get the risk score, the buyer's checklist and the guided inspection for the exact car you picked above — not the whole nameplate.

Toyota Auris E150Engine not picked yet

Pick the engine above first: the Auris came with 2, and without it the report has to show all of their faults. Pick the engine

Free. The paid plate check is separate, and stays optional.

Can't confirm for this car

Toyota Auris · 2006

Narrowed to the year. No engine is recorded for this vehicle. Pick an engine to see which faults apply.

Tell us the engine, or check the engine code on the car, before relying on this.

  • No engine is recorded for this vehicle.

matched on year only

All 3 issues for this one

Documented for the exact year and engine you picked. Tap an area to open it.

1 rated critical
Engine, transmission & cooling1 critical1

01Sticky accelerator pedal / floor mat entrapment recall era (E150, 2006-2010 build)

petrol2006–2010Engine
RareEngine ≈A$0–460 to fix

The Auris E150 was one of the eight European models in Toyota's January 2010 sticky accelerator pedal recall, covering cars built from October 2006 to early January 2010: the CTS-made pedal mechanism could wear and become slow to return or stick partially depressed, and the parallel floor-mat entrapment campaign covered unsecured mats trapping the pedal. Recalled cars had a precision steel reinforcement shim fitted free of charge. Important for Australian buyers: Japanese-market Auris used a different Denso pedal and were not recalled, so this mainly matters for UK-sourced imports and any car running cheap aftermarket floor mats. On any Auris of this era, confirm the recall status and never stack floor mats.

Symptoms to notice

  • Accelerator pedal feels rough, notchy or slow to spring back
  • Pedal catching on the edge of the floor mat
  • Engine revs hanging after you lift off the throttle
  • Unsecured or doubled-up driver's floor mats

What to check

With the engine off, press the accelerator pedal through its full travel several times and let it snap back - it should return instantly and smoothly every time. Lift the driver's floor mat: it should clip to the floor anchors and sit clear of the pedals. For a UK-sourced car, ask Toyota or a dealer to run the VIN for outstanding recall work (recall rectification is free even now).

Where to look: Accelerator pedal assembly in the driver's footwell

Ask the seller

  • “Is this car a Japanese import or UK import?”
  • “Has the VIN been checked for outstanding recalls?”
  • “Was the accelerator pedal recall work done - is it stamped or on the Toyota service record?”
Only with a certain gearbox: 1 issueEach one names the gearbox it affects, for example the CVT automatic. Check which gearbox this car has.

01Clutch wear/slip and notchy manual gearbox (E150)

petrol2006–2012Transmission
OccasionalTransmission ≈A$1,100–2,020 to fix

Can't confirm for this car

UK and European owner data flags clutch slipping and outright clutch failure as one of the recurring Auris E150 complaints, along with baulky or notchy manual gearshifts. Causes range from normal friction wear (accelerated by city driving) to clutch actuator and release bearing problems and old gearbox oil that was never changed. It is a full clutch kit replacement when it goes, and on an import with no service history there is no way to know how much clutch is left except by testing. The gearbox itself is robust once fresh oil is in it.

Symptoms to notice

  • Engine revs rising without the car accelerating, especially in 4th/5th gear up a hill
  • Burning smell after hill starts or towing
  • Clutch biting point very high near the top of pedal travel
  • Notchy or crunchy shifts into 2nd or 3rd, worst when cold
  • Judder pulling away from a stop

What to check

On the test drive, in 4th gear at about 50 km/h, floor the accelerator: if revs flare but speed doesn't build, the clutch is slipping and you should budget a full replacement. Feel where the clutch bites - high engagement means it is worn. Work through every gear including reverse, cold and warm. Ask whether the gearbox oil has ever been changed.

Where to look: Clutch and gearbox between engine and front wheels; test from the driver's seat

Parts involved: Clutch.

Ask the seller

  • “Has the clutch ever been replaced, and at what mileage?”
  • “Does it ever crunch going into 2nd or 3rd?”
  • “Has the gearbox oil been changed?”
Depends on the exact engine or version: 1 issueDocumented for a specific engine or version we could not confirm from what you picked. Check the engine code on the car.

01Super CVT-i / Multidrive shudder and hesitation from neglected fluid (JDM petrol CVT)

Drive the car from cold: shudder is usually worst in the first minutes.petrol2006–2018TransmissionRead the full fault: symptoms, where to look, what to ask the seller
Other Toyota Auris engines and years2 documented issues that do not apply to the one you picked.
Engine, transmission & cooling1

012ZR-FXE EGR/intake clogging, oil consumption and head gasket failure (Auris hybrid = Prius Gen 3 drivetrain)

Arrive for a stone-cold start.hybrid2012–2018EngineRead the full fault: symptoms, where to look, what to ask the seller
Electrical1

01Hybrid traction battery (NiMH) degradation and end-of-life failure

On the test drive, watch the energy screen: a healthy pack charges and discharges smoothly, a dying one bounces between extremes within minutes.hybrid2012–2018ElectricalRead the full fault: symptoms, where to look, what to ask the seller

Toyota Auris service schedule

The 2 engines a 2006 Toyota Auris was sold with, each with its own intervals. Pick your engine above to narrow this to one. These are the model’s intervals — the car’s own service book is the only thing that can tell you what has actually been done to it.

First Generation (E150) · 2006–2012 · 1.5L (1NZ-FE) - Standard/Entry trim

Petrol

Due by distance

  1. 100,000 km

    Flush the transmission fluid and check the condition of the serpentine belt.

  2. 150,000 km

    Suspension parts such as strut mounts or sway bar links are worth checking to keep the smooth Toyota ride.

  3. 200,000 km

    Have a mechanic you trust assess the oxygen sensors and the engine generally so fuel use stays low.

First Generation (E150) · 2006–2012 · 1.8L (2ZR-FE) - GX/GL trim

Petrol

Due by distance

  1. 100,000 km

    Time for a thorough check of the serpentine belt and the cooling system hoses.

  2. 150,000 km

    Good time to check the suspension bushings and shock absorbers for perishing.

  3. 200,000 km

    Review the spark plugs and make sure the fuel system has been kept clean.

Toyota Auris faults in detail

Narrowed to the Toyota Auris · 2006. Each of these has its own page: the symptoms, where to look, what to ask the seller and what the repair costs. Free, no account needed.

Super CVT-i / Multidrive shudder and hesitation from neglected fluid (JDM petrol CVT)Major · Transmission

Other Toyota models

Toyota RAV465 documented faultsToyota Prado64 documented faultsToyota Hilux60 documented faultsToyota Avanza5 documented faultsToyota Sienna5 documented faultsToyota Tundra5 documented faults

Toyota Auris buyer questions

Is the Toyota Auris reliable?

Like any used car, it depends on the specific example and its service history. Across the 5 documented faults for the Toyota Auris, the recurring problem areas are engine, electrical, and transmission. A Toyota Auris with a full service history and no signs of the issues listed on this page can be a sound buy but each one needs to be checked individually before you commit.

What are the most common problems with a used Toyota Auris?

We've catalogued 5 known faults for the Toyota Auris, covering engine, electrical, and transmission. All 5 are written out in full on this page, with the symptoms to notice, what to inspect, and typical repair costs for each. Free to read, no account needed.

How much do repairs cost on a Toyota Auris?

Most single repairs on the Toyota Auris fall between ≈A$370–4,140 at independent-workshop rates (an approximate guide in Australian dollars). Some of the 5 documented faults cost less and a few cost considerably more, and no one car needs them all. Knowing which ones to look for before you view is what lets you negotiate the price down or walk away.

Should I get a pre-purchase inspection on a Toyota Auris?

Yes. A Toyota Auris inspection focused on its known weak points is the single best way to avoid an expensive mistake. KickTyres gives you a guided, model-specific inspection with AI photo analysis from A$28.90, far less than the cost of missing one of the faults on this page. For a big purchase, a mechanic's pre-purchase inspection on the car you settle on is still worth it.