Skip to content
KickTyres
Isuzu2013–2024 Major issues documented

Isuzu MU-X 2nd: common faults & what to check

The 2nd is the Isuzu MU-X built 2021 onward. It was sold here with the 1.9 turbo-diesel and 3.0 turbo-diesel. Of the 10 faults documented for the MU-X, 5 apply to this generation, each with its symptoms, what to inspect and a typical repair cost. Free, no account needed.

Check this exact Isuzu MU-X

  • Odometer history
  • Money owing
  • Reported stolen
  • Ownership history
  • Official NZ vehicle register data
  • NZ owned and operated

Type the plate for the free basics. The full record is a paid check from $13.49, one car at a time, no subscription.

No NZ plate yet, or buying in Australia? Pick the generation and engine and start a free check below. New to KickTyres? How the check works →

10

Documented faults

Major

Most serious

$350–$1,600

Typical repair

4

Systems covered

You're looking at the 2nd

2 engine variants are documented for this generation. Pick yours to narrow further, or keep reading for the generation as a whole.

Choose a different generation

Now narrow it to the engine

A 1.8 and a 2.4 of the same car do not fail the same way, so the faults below narrow to the engine as well as the year. Free, no account needed.

A 2022 Isuzu MU-X is the 2nd generation (2021 to now).

Start your free check on this Isuzu MU-X

No plate needed. You get the risk score, the buyer's checklist and the guided inspection for the exact car you picked above — not the whole nameplate.

Isuzu MU-X 2ndEngine not picked yet

Pick the engine above first: the MU-X came with 2, and without it the report has to show all of their faults. Pick the engine

Free. The paid plate check is separate, and stays optional.

Can't confirm for this car

Isuzu MU-X · 2022

Narrowed to the year. No engine is recorded for this vehicle. Pick an engine to see which faults apply.

Tell us the engine, or check the engine code on the car, before relying on this.

  • No engine is recorded for this vehicle.

matched on year only

What to look out for

The checks worth doing on a Isuzu MU-X before you hand over any money. Every documented fault is listed below, each with its own page.

  • Costly issue

    Ask the owner how often the DPD regen message appears and what distance it covers between regens.

    See why

    DPF (DPD) frequent regeneration and blockage on short-trip vehicles

    From the 2017 update the MU-X runs Isuzu's DPD particulate filter, and both generations since are documented for regeneration trouble on vehicles that mostly do short urban trips. Owners report regen intervals collapsing from ~500 km to under 100 km, which burns fuel, dilutes engine oil with diesel, and can end in a blocked filter and limp mode; failing injectors that under-fuel the regen make it worse. The second-generation (2021+) DPD issues are well documented on Australian owner blogs and forums too. Watch the oil level - rising oil from failed regens is an engine killer.

    What you would notice

    • DPD/regeneration cycles happening every 100-200 km or less
    • Oil level rising above the full mark (fuel dilution)
    • Increased fuel consumption
    • DPD light flashing / limp mode

    Typically $500–$5,000 to put right.

  • Common issue

    On the test drive, use the open road and note any false warnings from the safety systems.

    See why

    ADAS/IDAS false alerts and infotainment glitches (RJ MU-X)

    The 2021+ MU-X introduced Isuzu's camera-based IDAS safety suite, and owner complaints centre on over-sensitive or false forward-collision warnings, lane-keep tugging on NZ/AU country roads, and the 9-inch infotainment unit freezing, rebooting or losing CarPlay connection. Software updates at dealers have progressively improved both. These are irritations rather than mechanical risk, but a head unit replacement out of warranty is not cheap and constant false alerts drive owners to disable safety systems.

    What you would notice

    • False collision warnings or phantom braking alerts
    • Lane-keep assist tugging on well-marked open roads
    • Head unit freezing or CarPlay dropping out

    Typically $0–$2,000 to put right.

See all 5 issues for this oneDocumented for the exact year and engine you picked.
Engine, transmission & cooling1

01DPF (DPD) frequent regeneration and blockage on short-trip vehicles

Ask the owner how often the DPD regen message appears and what distance it covers between regens.diesel2017 onwardEngineRead the full fault: symptoms, where to look, what to ask the seller
Electrical2

02ECM software fault causing engine stall - 2024 recall (RJ MU-X)

diesel2021–2024Electrical
OccasionalElectrical $0–$300 to fix

In August 2024 Isuzu recalled nearly 150,000 Australian D-Max and MU-X vehicles (2021-24) because an engine control module software fault could incorrectly reduce engine speed and stall the engine while driving, causing loss of drive. The fix is a free ECM software update at an Isuzu dealer. A 2023 recall (S202301) also covered 2021-22 MU-X for a lower steering shaft bolt that could lose tension and dislodge, risking loss of steering. Both are must-check items on the VIN before purchase.

Symptoms to notice

  • Engine stalling or cutting out while driving (pre-update)
  • Clunk or looseness in the steering column (steering shaft bolt)
  • No symptoms - many affected vehicles feel normal until the fault strikes

What to check

  1. Run the VIN through the Isuzu Utes NZ/AU recall lookup and confirm both the ECM software update and the steering shaft bolt inspection have been completed, with dealer paperwork.
  2. Feel for any play in the steering at a standstill.

Where to look: Engine control module (software); lower steering shaft in the driver footwell area

Ask the seller

  • “Have the 2023 steering shaft and 2024 ECM recalls been completed?”
  • “Has the engine ever stalled unexpectedly while driving?”

03ADAS/IDAS false alerts and infotainment glitches (RJ MU-X)

On the test drive, use the open road and note any false warnings from the safety systems.diesel2021 onwardElectrical
CommonElectrical $0–$2,000 to fix

The 2021+ MU-X introduced Isuzu's camera-based IDAS safety suite, and owner complaints centre on over-sensitive or false forward-collision warnings, lane-keep tugging on NZ/AU country roads, and the 9-inch infotainment unit freezing, rebooting or losing CarPlay connection. Software updates at dealers have progressively improved both. These are irritations rather than mechanical risk, but a head unit replacement out of warranty is not cheap and constant false alerts drive owners to disable safety systems.

Symptoms to notice

  • False collision warnings or phantom braking alerts
  • Lane-keep assist tugging on well-marked open roads
  • Head unit freezing or CarPlay dropping out

What to check

On the test drive, use the open road and note any false warnings from the safety systems. Work the touchscreen and phone pairing thoroughly. Ask if the dealer has applied the latest software updates to the IDAS and infotainment.

Where to look: Windscreen-mounted stereo camera; centre dash head unit

Ask the seller

  • “Have there been infotainment or safety-system software updates done?”
  • “Do the driver-assist systems false-alarm on your usual roads?”
Depends on the exact engine — 2 moreDocumented for a specific engine we could not confirm from what you picked. Check the engine code on the car.
Engine, transmission & cooling1

01ECM software recall: engine speed cut or stall (3.0 4JJ3-TCX diesel)

Ask the seller whether the engine computer software recall has been done and ask for the dealer invoice or service book stamp.diesel2021–2024Engine
RareEngine $0–$150 to fix

Can't confirm for this car

On second generation MU-X models with the 3.0 4JJ3-TCX diesel built from 2020 to 2024, the engine computer software that controls the fuel pump can wrongly reduce engine speed, so the engine may lose power or stall while driving. Isuzu Ute Australia recalled these vehicles in August 2024 (recall REC-006052) and dealers update the engine computer software free of charge. Isuzu described it as rare, but a stall in traffic is a safety risk, so a car that has not had the update should have it done before you rely on it. NZ recall coverage was not confirmed, so ask an Isuzu dealer to check the VIN.

Symptoms to notice

  • Engine suddenly loses power or revs drop while driving
  • Engine stalls and needs restarting
  • Sudden drop in revs with no warning light

What to check

Ask the seller whether the engine computer software recall has been done and ask for the dealer invoice or service book stamp. On the test drive, drive at steady speed and through gentle stops and pull aways, watching for any sudden drop in revs, hesitation or stall. Ask an Isuzu dealer to check the VIN for open recalls before you buy. If a workshop inspection is possible: have the dealer confirm the ECM software level and check for stored engine fault codes.

Where to look: Engine control module (engine computer) software; no physical part to see

Ask the seller

  • “Has the Isuzu engine computer software recall been done, and can I see the paperwork?”
  • “Has the engine ever lost power or stalled while driving?”
  • “Has an Isuzu dealer checked this VIN for open recalls?”
Fluid leaks1

01Front and Rear Differential Oil Seal Leaks (4WD Models)

Inspect both differential casings and pinion flanges for fresh oil seepage.diesel2013 onwardFluid Leaks
CommonFluid Leaks $280–$900 to fix

Can't confirm for this car

4WD MU-X variants develop differential pinion and axle output seal leaks from the front and rear differentials, particularly after off-road use or in higher-mileage examples. Seal degradation leads to gear oil weeping onto brake components or driveline parts. Loss of oil causes diff whine and eventual bearing failure if unaddressed.

Symptoms to notice

  • Gear oil smell underside after driving
  • Oily residue on differential housing or around axle flanges
  • Diff whine under load (advanced stage)
  • Low diff oil level on check

What to check

  1. Inspect both differential casings and pinion flanges for fresh oil seepage.
  2. Check rear axle flange seals and front CV boot roots for gear oil.
  3. Verify diff oil levels.
  4. Look for darkened contamination of brake dust on rear drums/discs.

Where to look: Front and rear differential housings, axle output flanges

Parts involved: Differential.

Ask the seller

  • “Has the vehicle done any off-road driving?”
  • “Have the differential oils ever been changed or checked?”
  • “Has any underside oil leak been noticed or repaired?”
Other Isuzu MU-X engines and years5 documented issues that do not apply to the one you picked.
Engine, transmission & cooling4

01Injector wear and suction control valve issues at high mileage (3.0 4JJ1)

Listen to the warm idle - it should be even and smooth for a diesel.diesel2013–2021Engine
OccasionalEngine $350–$4,000 to fix

Does not apply

The MU-X's 4JJ1 is one of the most durable diesels in the class, but at age and mileage the Denso common-rail injectors wear (rough idle, knock, poor economy, incomplete DPF regens on later cars) and injector seals can leak combustion gas. The suction control valve on the high-pressure pump is a known wear item causing rough idle, stalling and power loss, and is cheap compared with what it mimics. These are 200,000 km-era maintenance realities rather than design defects - a well-serviced high-km MU-X is routinely a better buy than a neglected low-km one.

A single common-rail diesel fuel injector photographed against a plain background.Example of the part — not this vehicle

A common-rail diesel injector. Contamination damages the nozzle at the tip.

Panoha · CC BY-SA 3.0 · Wikimedia Commons

Symptoms to notice

  • Rough or hunting idle
  • Diesel knock louder than usual
  • Stalling or power loss (SCV)
  • Black tar-like deposits around an injector base

What to check

  1. Listen to the warm idle - it should be even and smooth for a diesel.
  2. Ask for the full service history including fuel filter intervals and any injector or SCV work.
  3. A pre-purchase diagnostic scan showing injector correction values tells you the real story.

Where to look: Injectors under the top engine cover; SCV on the injection pump

Parts involved: Fuel injector.

Ask the seller

  • “Have the injectors or suction control valve ever been replaced?”
  • “How often were fuel filters changed?”
  • “Can I see injector balance rates on a scan?”

024JJ1-TCX DPF Blockage from Short-Trip Use

Inspect exhaust for soot deposits around DPF housing.diesel2013–2021Engine
CommonEngine $450–$3,800 to fix

Does not apply

The 3.0L 4JJ1-TCX diesel's diesel particulate filter blocks when the vehicle is used predominantly for short urban trips that do not reach exhaust temperatures required for passive regeneration. Active regen fails to complete if the trip ends mid-cycle, accelerating soot loading. Isuzu Australia issued dealer service advisories referencing minimum highway-speed run requirements.

Symptoms to notice

  • DPF warning light illuminated on dash
  • Reduced power / limp mode activation
  • Excessive black smoke under acceleration
  • Increased fuel consumption
  • Engine management light on

What to check

  1. Inspect exhaust for soot deposits around DPF housing.
  2. Ask owner for usage pattern — predominantly city driving is a red flag.
  3. If a workshop inspection is possible: Check DPF soot load percentage via OBD scan tool (Isuzu Tech 2 or equivalent).

Where to look: Exhaust system, underside of vehicle below driver's seat area

Parts involved: Diesel particulate filter.

Ask the seller

  • “Is this vehicle used mainly for short urban trips or regular highway driving?”
  • “Has the DPF warning light ever come on?”
  • “Has the DPF been professionally cleaned or replaced?”

03MU-X 4JJ1 EGR Cooler Coolant Ingestion

Inspect inside the intake air ducting and manifold for white or cream residue.diesel2013–2021CoolingRead the full fault: symptoms, where to look, what to ask the seller

04EGR Valve Carbon Sludge Blockage – 4JJ1-TC

Inspect air intake manifold for sludge coating.diesel2013–2019EngineRead the full fault: symptoms, where to look, what to ask the seller
Fluid leaks1

014JJ1 High-Pressure Injector Return Line Seal Failure

Remove engine cover and inspect injector return rail clip seals for cracking or fuel staining.diesel2013–2021Fluid Leaks
OccasionalFluid Leaks $550–$1,600 to fix

Does not apply

The plastic push-fit seals on the 4JJ1 diesel's high-pressure fuel injector return lines crack or harden over time, allowing diesel to leak back into the engine valley or drip onto hot exhaust components. Fuel contamination of the engine oil is a documented consequence where seals fail internally. Often misdiagnosed as a general oil leak.

A single common-rail diesel fuel injector photographed against a plain background.Example of the part — not this vehicle

A common-rail diesel injector. Contamination damages the nozzle at the tip.

Panoha · CC BY-SA 3.0 · Wikimedia Commons

Symptoms to notice

  • Fuel smell from engine bay
  • Visible fuel staining on engine valley cover or injector area
  • Oil dipstick showing diesel smell or raised level (fuel dilution)
  • Hard cold starts after standing

What to check

  1. Remove engine cover and inspect injector return rail clip seals for cracking or fuel staining.
  2. Smell the engine oil on the dipstick for diesel contamination.
  3. Check around each injector base for fresh fuel residue.

Where to look: Top of engine, fuel injector return rail, cylinder head area

Parts involved: Fuel injector.

Ask the seller

  • “Has the vehicle had any fuel or oil leak investigation?”
  • “When was the engine oil last changed and was it overdue?”
  • “Is there any fuel smell from the engine bay after a run?”

Isuzu MU-X faults in detail

Narrowed to the Isuzu MU-X · 2022. Each of these has its own page: the symptoms, where to look, what to ask the seller and what the repair costs. Free, no account needed.

DPF (DPD) frequent regeneration and blockage on short-trip vehiclesMajor · Engine

What these repairs cost on other cars

Some of the Isuzu MU-X’s documented faults are repairs other models share. Each page lists the documented NZ cost for every model it affects.

Other Isuzu models

Isuzu D-Max22 documented faultsIsuzu Bighorn12 documented faultsIsuzu Trooper5 documented faults

Isuzu MU-X buyer questions

Is the Isuzu MU-X reliable?

Like any used car, it depends on the specific example and its service history. Across the 10 documented faults for the Isuzu MU-X, the recurring problem areas are engine, cooling, and fluid leaks. A Isuzu MU-X with a full service history and no signs of the issues listed on this page can be a sound buy but each one needs to be checked individually before you commit.

What are the most common problems with a used Isuzu MU-X?

We've catalogued 10 known faults for the Isuzu MU-X, covering engine, cooling, and fluid leaks. All 10 are written out in full on this page, with the symptoms to notice, what to inspect, and typical repair costs for each. Free to read, no account needed.

How much do repairs cost on a Isuzu MU-X?

Most single repairs on the Isuzu MU-X fall between $350–$1,600 at NZ independent-workshop rates. Some of the 10 documented faults cost less and a few cost considerably more, and no one car needs them all. Knowing which ones to look for before you view is what lets you negotiate the price down or walk away.

Should I get a pre-purchase inspection on a Isuzu MU-X?

Yes. A Isuzu MU-X inspection focused on its known weak points is the single best way to avoid an expensive mistake. KickTyres gives you a guided, model-specific inspection plus a market valuation and negotiation figure for $24.90 far less than the cost of missing one of the faults on this page.